Pontiac G6 Forum banner

1 - 4 of 4 Posts

·
Registered
Joined
·
1 Posts
Discussion Starter #1
Panel #2 in my panoramic roof is loose. Everytime I close the driver's door from outside I can see the panel jump up! I can open the headliner and from inside push up on the panel and open it. Standing along side the car I can pry the panel open with my fingers. It is still attached along the front edge but the rear edge is just resting in place. I examined the mechanism and can see where pins on both ends of the rear edge appear to be missing. I wonder if these were some kind of a plastic shear pin that broke off when too much force was put on the panel while opening or closing. Anyone had experience with this?
 

·
Registered
Joined
·
1 Posts
I have 1 missing pin in my panoramic sun roof too. I took a photo of a panel with the pin in place - would like to find the art number for the pin - if not, I'll have one made at a machine shop
 

·
Registered
Joined
·
1 Posts
same problem

Panel #2 in my panoramic roof is loose. Everytime I close the driver's door from outside I can see the panel jump up! I can open the headliner and from inside push up on the panel and open it. Standing along side the car I can pry the panel open with my fingers. It is still attached along the front edge but the rear edge is just resting in place. I examined the mechanism and can see where pins on both ends of the rear edge appear to be missing. I wonder if these were some kind of a plastic shear pin that broke off when too much force was put on the panel while opening or closing. Anyone had experience with this?
I have the same problem, the pins came out on my second panel but i got lucky and still have the pins. i can push them back in place and it works for a little bit but then they just fall back out again. does anyone have any ideas on how re-secure the pins so they stay?
 
1 - 4 of 4 Posts
Top